Why Your Water Heater Needs A Filter System. A second look at pre-filtration for water heaters. What fits, what works, and what it actually costs.
Read the transcript ▼
hey everybody my name's Corbin I work with Titan Plumbing and Electric and today I'm going to be cutting open a 40G electric water heater that's 16 years old and we're going to take a look at all the sediment that's [Music] inside all right everybody I've cut open the 40 gon electric water heater now let's take a look at what's on the inside oh wow look at this scaling that is a ton of scaling now we've talked a lot on this channel about what scaling is and how we can get it out of the heater but a very important part of water heater maintenance is doing preventative filters we sell filter systems that we can install in your home that will catch the water coming into your home filter out all the stuff that causes this sediment and it can increase the quality of water in your home and increase the longevity of your water heaters so if you would like to get information on filtration systems to keep this out of your hot water give Titan pman electric a call at 813 933 810 or visit our website Titan plum electric.com [Music]
Why Your Water Heater Needs A Filter System — Tampa Water Heater Walkthrough
A second look at pre-filtration for water heaters. What fits, what works, and what it actually costs.
Tampa Bay water sits at 7–10 grains-per-gallon hardness, which is the main reason residential water heaters here fail at year 10–12 instead of the 15-year industry average. Sediment buries the lower element, the anode rod corrodes early, and the tank's bottom rusts from the inside. The video above shows what we see on a typical service call — and what we recommend doing about it.
Why Tampa Bay water destroys tanks faster
Hard water is the single biggest factor shortening water-heater life in Hillsborough, Pinellas, and Pasco counties. The minerals settle out as the water heats, building a layer at the bottom of the tank that insulates the lower heating element from the water it's supposed to warm. The element runs longer to compensate, the bottom of the tank scales over, and efficiency drops noticeably year over year.
By the time most homeowners notice ('the hot water doesn't last like it used to'), the tank usually has 1–3 inches of sediment, a rusted lower element, and an anode rod that's been gone for years. That's not a repair situation, that's an end-of-life signal.
How Titan replaces a water heater the right way
We size the new unit on actual demand, not just gallon count — fixture units, simultaneous draws, recovery rate. We pull the Hillsborough County (or local-jurisdiction) permit so the install is inspected and warranty-registered. We replace the supply lines, install a proper drip pan with a routed drain, and confirm the T&P discharge runs to a safe location.
If the failed unit was electric and your panel has spare capacity, the swap is usually a same-day job. If you're upgrading from tank to tankless, we evaluate panel capacity, gas line sizing, and venting before we quote so you're not surprised on install day.
- Proper sizing:fixture units, simultaneous draws, recovery rate
- Permit pulled, installation inspected by the county
- New supply lines, drip pan, routed drain
- T&P discharge routed to a code-compliant termination
- Manufacturer warranty registered in your name
Key takeaways
What this video covers in plain English
If your tank is past year eight and has never been flushed, the video above is what's happening inside it right now. These are the practical takeaways — what to do before the tank fails, and what changes when it does.
- Tampa hard water leaves 1–3 inches of sediment inside an unflushed tank by year ten
- Annual flushing typically extends tank life by 3–5 years
- Replacement sizing is about fixture demand, not gallon count alone
- Permitted, inspected installs are how the manufacturer warranty stays valid
Tampa Bay · Same-day service
Have a job like the one in the video?
Real Titan technicians, never sub-contracted. Flat-rate pricing quoted before any work begins. A+ BBB rated, family-owned since 1994.
More water heaters videos
Upgrade Your Water Heater And Save Big
Tampa hard water builds inches of sediment inside a typical residential water heater. Watch the Titan crew cut one open on a real Tampa job, count the scoops of sediment pulled out, take $100 off the new install for every cup (up to $500 off), and recommend the right filter system so it doesn't happen again.
Cutting Open A 40 Gal Water Heater
See what the inside of a 40-gallon water heater really looks like after years of Tampa hard water. Sediment, scale, and corrosion that quietly destroy efficiency.
Big Savings On A Water Heater
How a properly sized, energy-efficient water heater pays for itself in lower bills and longer service life.
